The most common household toasters are the pop-up toaster and the toaster oven. A third type, most commonly found in restaurants, has a metal-mesh conveyor belt that moves the bread past constantly-powered heat elements.
In pop-up or automatic toasters, a single vertical piece of bread is dropped into a slot on the top of the toaster. A lever on the side of the toaster is pressed down, lowering the bread into the toaster and activating the heating elements. The length of the toasting cycle (and therefore the degree of toasting) is adjustable via a lever, knob, or series of pushbuttons, and when an internal device determines that the toasting cycle is complete, the toaster turns off and the toast pops up out of the slots.
In earlier days, the completion of the toasting operation was determined by a mechanical clockwork timer; the user could adjust the running time of the timer to determine the degree of toasting, but the first cycle produced less toasted toast than subsequent cycles because the toaster was not yet warmed up. Toasters made since the 1920s frequently use a thermal sensor, such as a bimetallic strip, located close to the toast. This allows the first cycle to run longer than subsequent cycles. The thermal device is also slightly responsive to the actual temperature of the toast itself. Like the timer, it can be adjusted by the user to determine the doneness of the toast. Toasters may also use an electronic control, where an electromagnet holds the pop-up mechanism until an adjustable time delay has passed.
Toasters may also be used to toast other foods such as teacakes, toaster pastry, potato waffles and crumpets, though resultant accumulation of fat and sugar inside the toaster can contribute to its eventual failure.
Among pop-up toasters, those toasting two slices of bread are more purchased than those which can toast four. Pop-up toasters can have a range of appearances beyond just a square box, and may have an exterior finish of chrome, copper, brushed metal, or any color plastic. The marketing and price of toasters may not be an indication of quality for producing good toast. A typical modern two-slice pop-up toaster can draw from 600 to 1200 watts.
Beyond the basic toasting function, some pop-up toasters offer additional features such as:
- One-sided toasting, which some people prefer when toasting bagels
- The ability to power the heat elements in only one of the toaster's several slots
- Slots of various depth, length, and width to accommodate a variety of bread types
- Provisions to allow the bread to be lifted higher than the normal raised position, so toast that has shifted during the toasting process can safely and easily be removed
Toaster ovens are essentially small-scale conventional ovens and can be used to cook foods other than just toasting. A frontal door is opened, horizontally-oriented bread slices (or other food items) are placed on a rack which has heat elements above and below it, and the door is closed. The controls are set and actuated to toast the bread to the desired doneness, whereupon the heat elements are switched off. In most cases the door must be opened manually, though there are also toaster ovens with doors that open automatically. Because the bread is horizontal, a toaster oven can be used to cook toast with toppings, like garlic bread, melt sandwiches, or toasted cheese. Toaster ovens are generally slower to make toast than pop-up toasters, taking 4–6 minutes as compared to 2–3 minutes. In addition to the automatic-toasting settings, toaster ovens typically have settings and temperature controls to allow use of the appliance as a small oven.
Extra features on toaster ovens can include:
- Heating element control options, such as a "top brown" setting that powers only the upper elements so food can be broiled without heat from below.
- Multiple shelf racks – Having options for positioning the oven shelf gives more control over distance between food and the heating element.
Conveyor toasters are designed to make many slices of toast and are generally used in the catering industry, restaurants, cafeterias, institutional cooking facilities, and other commercial food service situations where constant or high-volume toasting is required. Bread is toasted at a rate of 300–1600 slices an hour; the doneness control on such a toaster adjusts the conveyor speed, thus altering the time during which the bread is near the heat elements. Conveyor toasters have been produced for home use; in 1938, for example, the Toast-O-Lator went into limited production.
Before the development of the electric toaster, sliced bread was toasted by placing it in a metal frame or on a long-handled toasting-fork and holding it near a fire or over a kitchen grill. Utensils for toasting bread over open flames appeared in the early 19th century, including decorative implements made from wrought iron.
Development of the heating elementEdit
The primary technical problem in toaster development at the turn of the 20th century was the development of a heating element which would be able to sustain repeated heating to red-hot temperatures without breaking or becoming too brittle. A similar technical challenge had recently been surmounted with the invention of the first successful incandescent lightbulbs by Joseph Swan and Thomas Edison. However, the light bulb took advantage of the presence of a vacuum, something that couldn't be used for the toaster.
Macmasters' toaster was commercialized by the Crompton, Stephen J. Cook & Company of the UK as a toasting appliance called the Eclipse. Early attempts at producing electrical appliances using iron wiring were unsuccessful, because the wiring was easily melted and a serious fire hazard. Meanwhile, electricity was not readily available, and when it was, it was usually only available at night.
The first US patent application for an electric toaster was filed by George Schneider of the American Electrical Heater Company of Detroit in collaboration with Marsh. One of the first applications that the Hoskins company had considered for its Chromel wire was for use in toasters, but the company eventually abandoned such efforts, to focus on making just the wire itself.
Dual-side toasting and automated pop-up technologiesEdit
In 1913, Lloyd Groff Copeman and his wife Hazel Berger Copeman applied for various toaster patents, and in that same year, the Copeman Electric Stove Company introduced a toaster with an automatic bread turner. Before this, electric toasters cooked bread on one side, meaning the bread needed to be flipped by hand in order to cook both sides. Copeman's toaster turned the bread around without having to touch it.
The automatic pop-up toaster, which ejects the toast after toasting it, was first patented by Charles Strite in 1921. In 1925, using a redesigned version of Strite's toaster, the Waters Genter Company introduced the Model 1-A-1 Toastmaster, the first automatic, pop-up, household toaster that could brown bread on both sides simultaneously, set the heating element on a timer, and eject the toast when finished.
Toasting technology after the 1940sEdit
By the middle of the 20th century, some high-end U.S. toasters featured automatic toast lowering and raising, without the need to operate levers — simply dropping the bread into one of these "elevator toasters", such as the Sunbeam Radiant Control toaster models made from the late 1940s through the 1960s, begins the toasting cycle. These toasters use the mechanically multiplied thermal expansion of the resistance wire in the center element assembly to lower the bread; the inserted slice of bread trips a lever switch to activate the heating elements, and their thermal expansion is harnessed to lower the bread.
When the toast is done, as determined by a small bimetallic sensor actuated by the heat passing through the toast, the heaters are shut off and the pull-down mechanism returns to its room-temperature position, slowly raising the finished toast. This sensing of the heat passing through the toast means that regardless of the type of bread (white or whole grain) or its initial temperature (even frozen), the bread is always toasted to the same consistency.
Toasters cause nearly 800 deaths annually due to electrocution and fires. Poking knives and other objects into a toaster is dangerous; aside from a risk of electrocution, such insertion can damage the toaster in ways that can increase the risk that the toaster will later start a fire. Even without such tampering, toasters can cause house fires.
A number of projects have added advanced technology to toasters. In 1990, Simon Hackett and John Romkey created "The Internet Toaster," a toaster which could be controlled from the Internet. In 2001, Robin Southgate from Brunel University in England created a toaster that could toast a graphic of the weather prediction (limited to sunny or cloudy) onto a piece of bread. The toaster dials a pre-coded phone number to get the weather forecast.
In 2005, Technologic Systems, a vendor of embedded systems hardware, designed a toaster running the NetBSD Unix-like operating system as a sales demonstration system. In 2012, Basheer Tome, a student at Georgia Tech, designed a toaster using color sensors to toast bread to the exact shade of brown specified by a user.
A hot dog toaster is a variation on the toaster design; it will cook hot dogs without use of microwaves or stoves. The appliance looks similar to a regular toaster, except that there are two slots in the middle for hot dogs, and two slots on the outside for toasting the buns.
- Consumer Reports (November 2012). "Toaster Buying Guide". consumerreports.org. Retrieved 17 March 2014.
- "Automatic Toaster Guide-Melpomene.org-". www.melpomene.org. Archived from the original on 17 June 2018. Retrieved 29 January 2017.
- "Toast-O-Lator Electric Toaster by Crocker Wheeler Co., 1939 - The Henry Ford". www.thehenryford.org. Retrieved 2018-11-26.
- Snodgrass, Mary Ellen (2004-11-29). Encyclopedia of Kitchen History. Taylor & Francis. p. 392. ISBN 9781579583804.
- "The Howard Roth Collection of Early American Iron | Skinner Auctions 2744M, 2743T and 2757B". issuu. Retrieved 2017-07-18.
- Gross, Linda (13 June 2017). "The History of Making Toast". Hagley Museum and Library.
- Myall, Steve. "Made in the UK: The life-changing everyday innovations which put British guy on the map". Daily Mirror. Trinity Mirror plc. Retrieved 2013-02-16.
- U.S. Patent 811,859
- Norcross, Eric (2006). "The Cyber Toaster Museum". Toaster.org. The Toaster Museum Foundation. pp. section "1900–1920". Archived from the original on 2008-08-15. Retrieved 2008-08-16.
- George, William F. (2003). Antique Electric Waffle Irons 1900–1960: A History of the Appliance Industry in 20th Century America. Trafford Publishing. p. 20. ISBN 1-55395-632-X. Retrieved 2008-08-16.
- Clark, Neil M. (May 1927). "The World's Most Tragic Man Is the One Who Never Starts". The American. Archived from the original on 2006-08-25. Retrieved 2007-02-24.; republished in hotwire: The Newsletter of the Toaster Museum Foundation, vol. 3, no. 3, online edition.
- Schneider, George (17 July 1906) "Electric cooker" U.S. Patent 825,938
- Dana Gloger (2009-03-31). "A Toast to the Toaster... 100 Years Old and Still Going Strong". Daily Express. Retrieved 2009-03-31.
- F. E. Shailor (22 February 1910) "Electric heater" U.S. Patent 950,058
- Copeman, Kent L. "Lloyd Groff Copeman". LloydCopeman.com. Retrieved October 18, 2011.
- "Lloyd Groff Copeman: The Patent Man". Absolute Michigan. Leelanau Communications, Inc. May 5, 2006. Retrieved October 18, 2011.
- United States patent 1,394,450, "Bread-Toaster", 1921
- "Toastmaster Toasters: When They Were Made". Toaster Museum Foundation. Retrieved October 19, 2011.
- Doyle, Alister (17 January 2008). "Toasters deadlier than sharks?". Reuters. Retrieved 5 April 2016.
- Q.E.D. (9 September 2003). "Is poking a knife into the toaster really dangerous?". The Straight Dope.
- "Appliance fires". Consumer Reports. March 2012.
- "savetz.com". Internet Toaster, John Romkey, Simon Hackett. Retrieved 25 November 2008.
- "A small slice of design". BBC News. 2001-04-06. Retrieved 2010-05-25.
- Orlowski, Andrew (June 4, 2001). "Bread as a display device – we have pictures". The Register. Retrieved October 19, 2011.
- "NetBSD Toaster with the TS-7200 ARM9 SBC". Technologic Systems. Retrieved October 19, 2011.
- "Color-Sensing Toasters? A Student Reimagines the Home". BloombergBusinessweek. Retrieved December 28, 2012.
- Costanzo, Sam (July 25, 2013). "This high-tech toaster can Tweet". The Boston Globe. Boston: NYTC. ISSN 0743-1791. Retrieved 17 March 2014.
- Ganapati, Priya (5 August 2009). "Toaster, Toilet Lead Appliance Invasion of Twitter". wired.com. Retrieved 17 March 2014.
- Murphy Kelly, Samantha (Aug 26, 2013). "Eat What You Tweet: Toaster Strudel Personalizes Pastries on Twitter". mashable.com. Retrieved 17 March 2014.
- Kraft, Caleb (October 22, 2008). "Reflowing with a toaster". Hack a Day. Retrieved October 19, 2011.
- "Honorable Mention". DesignStellaris2006. Retrieved October 19, 2011.
|Wikimedia Commons has media related to Toasters.|