Ram air turbine
This article needs additional citations for verification. (January 2009) (Learn how and when to remove this template message)
A ram air turbine (RAT) is a small wind turbine that is connected to a hydraulic pump, or electrical generator, installed in an aircraft and used as a power source. The RAT generates power from the airstream by ram pressure due to the speed of the aircraft.
Modern aircraft generally use RATs only in an emergency. In case of the loss of both primary and auxiliary power sources the RAT will power vital systems (flight controls, linked hydraulics and also flight-critical instrumentation). Some RATs produce only hydraulic power, which is in turn used to power electrical generators.
In some early aircraft (including airships), small RATs were permanently mounted and operated a small electrical generator or fuel pump. Some constant-speed propellers, such as those of the Argus As 410 engines used in the Focke-Wulf Fw 189, used a propeller turbine on the spinner to power a self-contained pitch governor controlling this constant speed.
Modern aircraft generate power in the main engines or an additional fuel-burning turbine engine called an auxiliary power unit, which is often mounted in the rear of the fuselage or in the main-wheel well. The RAT generates power from the airstream due to the speed of the aircraft. If aircraft speeds are low, the RAT will produce less power. In normal conditions the RAT is retracted into the fuselage (or wing), and is deployed manually or automatically following complete loss of power. In the time between power loss and RAT deployment, batteries are used.
RATs are common in military aircraft which must be capable of surviving sudden and complete loss of power.
In other military uses, pod-fitted systems such as the M61A1 Vulcan cannon or high-powered electronics such as the AN/ALQ-99 jamming system can be powered by a RAT in standard operation. This allows their installation on a standard hardpoint, without requiring a pod-specific power supply. Also, some free-fall nuclear weapons, such as the British Yellow Sun and Blue Danube, used RATs to power radar altimeters and firing circuits; these were a more reliable alternative to batteries.
Many modern types of commercial airliners, from the Vickers VC10 of the 1960s, are also equipped with RATs. A ram air turbine was chosen for the VC10 because of its use of 'packaged' hydraulically-powered flying controls, rather than an overall valve-ram system, with centralised hydraulic power and a hydraulic emergency reserve system. A fully powered flying control system such as that of the VC10, rare on civilian aircraft up to that point, would require an excessively large hydraulic power reserve, with its own risks of failure. The individual package units of the VC10 were each powered electrically and so emergency redundancy for the VC10 relied instead on quadruple generators and a backup RAT.
The Airbus A380 has the largest RAT propeller in the world at 1.63 metres (5.3 ft) in diameter, but around 80 centimetres (2.6 ft) is more common. A typical large RAT on a commercial aircraft can be capable of producing, depending on the generator, from 5 to 70 kW. Smaller, low airspeed models may generate as little as 400 watts.
RATs have also been used to power centrifugal pumps to pressurize the spray systems on aircraft that are used as crop dusters to deliver liquid agents to cropland. The major reason for choosing a RAT is safety; using a RAT allows, in the case of the US, the FAA-certified engine and power systems on the aircraft to remain unmodified. There is no need to use an engine power takeoff to drive the pump, as the pump can be placed low or below the exterior of the airframe greatly simplifying plumbing. Being the lowest point in the plumbing, it will have gravity feed from the spray tanks and never need to be primed. In the event of a pump failure that could result in seizure, there is no effect on the flying ability of the aircraft or its systems apart from the fact that the spray systems are non-functional.
Civilian incidents involving RAT deploymentEdit
The following aviation incidents involved the deployment of a ram air turbine:
- "FAA Aircraft Aviation Maintenance Technician Handbook - Airframe. Chapter 12 Hydraulic and Pneumatic Power Systems. Ram Air Turbine (RAT)" (PDF). Federal Aviation Administration (FAA). 2012. p. 35.
- "Vicker VC10". Flight International: 728–742. 10 May 1962.
- "Flying-Control Systems". Flight International: 485. 26 September 1968.
- Wald, Matthew L. (2009-01-17). "Investigators Offer Details of Flight's Few Minutes". Manhattan (NYC): NYTimes.com. Retrieved 2009-01-20.
|Wikimedia Commons has media related to Ram air turbines.|
- on YouTube
- A survey on the use of ram air turbine in aircraft / AIP Conference Proceedings > Volume 1831, Issue 1 (2017) doi:10.1063/1.4981189