Diatomaceous earth ( / /, DE), diatomite or kieselgur/kieselguhr is a naturally occurring, soft, siliceous sedimentary rock that is crumbled into a fine white to off-white powder. It has a particle size ranging from less than 3 μm to more than 1 mm, but typically 10 to 200 μm. Depending on the granularity, this powder can have an abrasive feel, similar to pumice powder, and has a low density as a result of its high porosity. The typical chemical composition of oven-dried diatomaceous earth is 80–90% silica, with 2–4% alumina (attributed mostly to clay minerals) and 0.5–2% iron oxide.
Diatomaceous earth consists of fossilized remains of diatoms, a type of hard-shelled protist. It is used as a filtration aid, mild abrasive in products including metal polishes and toothpaste, mechanical insecticide, absorbent for liquids, matting agent for coatings, reinforcing filler in plastics and rubber, anti-block in plastic films, porous support for chemical catalysts, cat litter, activator in blood clotting studies, a stabilizing component of dynamite, a thermal insulator, and a soil for potted plants and trees like bonsai.
Each deposit of diatomaceous earth is different, with varying blends of pure diatomaceous earth combined with other natural clays and minerals. The diatoms in each deposit contain different amounts of silica, depending on the age of the deposit. The species of diatom may also differ among deposits. The species of diatom is dependent upon the age and paleoenvironment of the deposit. In turn, the shape of a diatom is determined by its species.
Many deposits throughout British Columbia, such as Red Lake Earth, are from the Miocene epoch and contain a species of diatom known as Melosira granulata. These diatoms are approximately 12 to 13 million years old and have a small globular shape. A deposit containing diatoms from this epoch can provide many more benefits than that of an older deposit. For example, diatoms from the Eocene epoch (approximately 40 to 50 million years old) are not as effective in their ability to absorb fluids because older diatoms recrystallize, their small pores becoming filled with silica.
Diatomite forms by the accumulation of the amorphous silica (opal, SiO2·nH2O) remains of dead diatoms (microscopic single-celled algae) in lacustrine or marine sediments. The fossil remains consist of a pair of symmetrical shells or frustules.
In 1836 or 1837, German peasant Peter Kasten discovered diatomaceous earth (German: Kieselgur) when sinking a well on the northern slopes of the Haußelberg hill, in the Lüneburg Heath in North Germany.
Extraction and storage sites in the Lüneburg Heath
- Neuohe – extraction from 1863 to 1994
- Wiechel from 1871 to 1978
- Hützel from 1876 to 1969
- Hösseringen from c.1880 to 1894
- Hammerstorf from c.1880 to 1920
- Oberohe from 1884 to 1970
- Schmarbeck from 1896 to c. 1925
- Steinbeck from 1897 to 1928
- Breloh from 1907 to 1975
- Schwindebeck from 1913 to 1973
- Hetendorf from 1970 to 1994
The deposits are up to 28 metres (92 ft) thick and are all of freshwater diatomaceous earth.
Until the First World War almost the entire worldwide production of diatomaceous earth was from this region.
There is a layer of diatomaceous earth up to 4 metres (13 ft) thick in the nature reserve of Soos in the Czech Republic.
In Colorado and in Clark County, Nevada, United States, there are deposits that are up to several hundred metres thick in places. Marine deposits have been worked in the Sisquoc Formation in Santa Barbara County, California near Lompoc and along the Southern California coast. Additional marine deposits have been worked in Maryland, Virginia, Algeria and the MoClay of Denmark. Freshwater lake deposits occur in Nevada, Oregon, Washington and California. Lake deposits also occur in interglacial lakes in the eastern United States, in Canada and in Europe in Germany, France, Denmark and the Czech Republic. The worldwide association of diatomite deposits and volcanic deposits suggests that the availability of silica from volcanic ash may be necessary for thick diatomite deposits.
Diatomaceous earth is sometimes found on desert surfaces. Research has shown that the erosion of diatomaceous earth in such areas (such as the Bodélé Depression in the Sahara) is one of the most important sources of climate-affecting dust in the atmosphere.
The siliceous frustules of diatoms accumulate in fresh and brackish wetlands and lakes. Some peats and mucks contain a sufficient abundance of frustules that they can be mined. Most of Florida's diatomaceous earths have been found in the muck of wetlands or lakes. The American Diatomite Corporation, from 1935 to 1946, refined a maximum of 145 tons per year from their processing plant near Clermont, Florida. Muck from several locations in Lake County, Florida was dried and burned (calcined) to produce the diatomaceous earth. It was formerly extracted from Lake Mývatn in Iceland.
Diatomaceous earth is available commercially in several formats:
In 1866, Alfred Nobel discovered that nitroglycerin could be made much more stable if absorbed in diatomite. This allows much safer transport and handling than nitroglycerin in its raw form. He patented this mixture as dynamite in 1867; the mixture is also called guhr dynamite.
The Celle engineer Wilhelm Berkefeld recognized the ability of the diatomaceous earth to filter, and he developed tubular filters (known as filter candles) fired from diatomaceous earth. During the cholera epidemic in Hamburg in 1892, these Berkefeld filters were used successfully. One form of diatomaceous earth is used as a filter medium, especially for swimming pools. It has a high porosity because it is composed of microscopically small, hollow particles. Diatomaceous earth (sometimes referred to by trademarked brand names such as Celite) is used in chemistry as a filtration aid, to increase flow rate and filter very fine particles that would otherwise pass through or clog filter paper. It is also used to filter water, particularly in the drinking water treatment process and in fish tanks, and other liquids, such as beer and wine. It can also filter syrups, sugar, and honey without removing or altering their color, taste, or nutritional properties.
- Pest control
Diatomite is of value as an insecticide, because of its abrasive and physico-sorptive properties. The fine powder adsorbs lipids from the waxy outer layer of the exoskeletons of many species of insects; this layer acts as a barrier that resists the loss of water vapour from the insect's body. Damaging the layer increases the evaporation of water from their bodies, so that they dehydrate, often fatally.
Arthropods die as a result of the water pressure deficiency, based on Fick's law of diffusion. This also works against gastropods and is commonly employed in gardening to defeat slugs. However, since slugs inhabit humid environments, efficacy is very low. Diatomaceous earth is sometimes mixed with an attractant or other additives to increase its effectiveness.
The shape of the diatoms contained in a deposit has not been proven to affect their functionality when it comes to the adsorption of lipids; however, certain applications, such as that for slugs and snails, do work best when a particular shaped diatom is used, suggesting that lipid adsorption is not the whole story. For example, in the case of slugs and snails large, spiny diatoms work best to lacerate the epithelium of the mollusk. Diatom shells will work to some degree on the vast majority of animals that undergo ecdysis in shedding cuticle, such as arthropods or nematodes. It also may have other effects on lophotrochozoans, such as mollusks or annelids.
Medical-grade diatomite has been studied for its efficacy as a deworming agent in cattle; in both studies cited the groups being treated with diatomaceous earth did not fare any better than control groups. It is commonly used in lieu of boric acid, and can be used to help control and possibly eliminate bed bug, house dust mite, cockroach, ant and flea infestations.
Diatomaceous earth is widely applied for insect control in grain storage.
In order to be effective as an insecticide, diatomaceous earth must be uncalcinated (i.e., it must not be heat-treated prior to application) and have a mean particle size below about 12 μm (i.e., food grade—see below).
Although considered to be relatively low-risk, pesticides containing diatomaceous earth are not exempt from regulation in the United States under the Federal Insecticide, Fungicide, and Rodenticide Act and must be registered with the Environmental Protection Agency.
Its thermal properties enable it to be used as the barrier material in some fire resistant safes. It is also used in evacuated powder insulation for use with cryogenics. Diatomaceous earth powder is inserted into the vacuum space to aid in the effectiveness of vacuum insulation. It was used in the classical AGA cookers as a thermal heat barrier.
- Catalyst support
Diatomaceous earth also finds some use as a support for catalysts, generally serving to maximize a catalyst's surface area and activity. For example, nickel can be supported on the material—the combination is called Ni–Kieselguhr—to improve its activity as a hydrogenation catalyst.
Natural freshwater diatomaceous earth is used in agriculture for grain storage as an anticaking agent, as well as an insecticide. It is approved by the Food and Drug Administration as a feed additive to prevent caking.
Some believe it may be used as a natural anthelmintic (dewormer), although studies have not shown it to be effective. Some farmers add it to their livestock and poultry feed to prevent the caking of feed. "Food-Grade Diatomaceous Earth" is widely available in agricultural feed supply stores.
Freshwater diatomite can be used as a growing medium in hydroponic gardens.
It is also used as a growing medium in potted plants, particularly as bonsai soil. Bonsai enthusiasts use it as a soil additive, or pot a bonsai tree in 100% diatomaceous earth. In vegetable gardening it is sometimes used as a soil conditioner, because like perlite, vermiculite, and expanded clay, it retains water and nutrients, while draining fast and freely, allowing high oxygen circulation within the growing medium.
- Marker in livestock nutrition experiments
Natural dried, not calcinated diatomaceous earth is regularly used in livestock nutrition research as a source of acid insoluble ash (AIA), which is used as an indigestible marker. By measuring the content of AIA relative to nutrients in test diets and feces or digesta sampled from the terminal ileum (last third of the small intestine) the percentage of that nutrient digested can be calculated using the following equation:
Natural freshwater diatomaceous earth is preferred by many researchers over chromic oxide, which has been widely used for the same purpose, the latter being a known carcinogen and, therefore, a potential hazard to research personnel.
Diatomaceous earth is considered a very prominent inorganic non-metallic material that can be utilized for the production various ceramics, including production of porous ceramics under low temperature hydrothermal technology.
- Tripolite is the variety found in Tripoli, Libya.
- Bann clay is the variety found in the Lower Bann valley in Northern Ireland.
- Moler (Mo-clay) is the variety found in northwestern Denmark, especially on the islands of Fur and Mors.
- Freshwater-derived food grade diatomaceous earth is the type used in United States agriculture for grain storage, as feed supplement, and as an insecticide. It is produced uncalcinated, has a very fine particle size, and is very low in crystal silica (<2%).
- Salt-water-derived pool / beer / wine filter grade is not suitable for human consumption or effective as an insecticide. Usually calcinated before being sold to remove impurities and undesirable volatile contents, it is composed of larger particles than the freshwater version and has a high crystalline silica content (>60%).
Certain species of bacteria in oceans and lakes can accelerate the rate of dissolution of silica in dead and living diatoms; by using hydrolytic enzymes to break down the organic algal material.
The Earth's climate is affected by dust in the atmosphere, so locating major sources of atmospheric dust is important for climatology. Recent research indicates that surface deposits of diatomaceous earth play an important role. Research shows that significant dust comes from the Bodélé Depression in Chad, where storms push diatomite gravel over dunes, generating dust by abrasion.
Inhalation of crystalline silica is harmful to the lungs, causing silicosis. Amorphous silica is considered to have low toxicity, but prolonged inhalation causes changes to the lungs. Diatomaceous earth is mostly amorphous silica, but contains some crystalline silica, especially in the saltwater forms. In a study of workers, those exposed to natural D.E. for over 5 years had no significant lung changes, while 40% of those exposed to the calcined form had developed pneumoconiosis. Today's common D.E. formulations are safer to use as they are predominantly made up of amorphous silica and contain little or no crystalline silica.
The crystalline silica content of D.E. is regulated in the United States by the Occupational Safety and Health Administration (OSHA), and there are guidelines from the National Institute for Occupational Safety and Health setting maximum amounts allowable in the product (1%) and in the air near the breathing zone of workers, with a recommended exposure limit at 6 mg/m3 over an 8-hour workday. OSHA has set a permissible exposure limit for diatomaceous earth as 20 mppcf (80 mg/m3/%SiO2). At levels of 3000 mg/m3, diatomaceous earth is immediately dangerous to life and health.
In the 1930s, long-term occupational exposure among workers in the cristobalite D.E. industry who were exposed to high levels of airborne crystalline silica over decades were found to have an increased risk of silicosis.
Today, workers are required to use respiratory-protection measures when concentrations of silica exceed allowable levels.
- Biomineralization – Process by which living organisms produce minerals
- Diatom – A class of microalgae, found in the oceans, waterways and soils of the world
- Fuller's earth – Any clay material that can decolorise oil or other liquids
- Perlite – Amorphous volcanic glass
- Rock flour
- Silica aerogel
- Siliceous ooze
- Zeolite – Microporous, aluminosilicate minerals commonly used as commercial adsorbents and catalysts
- Antonides, Lloyd E. (1997). Diatomite (PDF). USGS. Retrieved December 12, 2010.
- Reka, Arianit A.; Pavlovski, Blagoj; Ademi, Egzon; Jashari, Ahmed; Boev, Blazo; Boev, Ivan; Makreski, Petre (December 31, 2019). "Effect Of Thermal Treatment Of Trepel At Temperature Range 800-1200˚C". Open Chemistry. 17 (1): 1235–1243. doi:10.1515/chem-2019-0132.
- Reka, Arianit; Anovski, Todor; Bogoevski, Slobodan; Pavlovski, Blagoj; Boškovski, Boško (December 29, 2014). "Physical-chemical and mineralogical-petrographic examinations of diatomite from deposit near village of Rožden, Republic of Macedonia". Geologica Macedonica. 28 (2): 121–126.
- "Diatoms". UCL London's Global University. Retrieved September 14, 2011.
- "History of Diatoms – What Is Diatomaceous Earth". Diatomaceous. Diatomaceous Organization. Retrieved October 12, 2018.[better source needed]
- "Diatomaceous Earth (one of my new favorite products)". Homesteading Stewards. June 5, 2012. Retrieved October 12, 2018.[better source needed]
- Klebs, Florian (December 17, 2001). "Deutschland - Wiege des Nobelpreis: Tourismus-Industrie und Forschung auf den Spuren Alfred Nobels" (in German). Alexander von Humboldt Foundation. Archived from the original on November 17, 2002. Retrieved October 12, 2018.
- "Was ist es um die Kieselgur?". Archived from the original on September 28, 2007. Retrieved March 10, 2010. Über den früheren Abbau von Kieselgur im Vogelsberg/Hessen
- Geschichte des Kieselgurabbaus in Klieken Archived April 20, 2008, at the Wayback Machine
- "SKYE DIATOMITE: A LOST INDUSTRY". www.stornowaygazette.co.uk.
- Cummins, Arthur B., Diatomite, in Industrial Minerals and Rocks, 3rd ed. 1960, American Institute of Mining, Metallurgical, and Petroleum Engineers, pp. 303–319
- Davis, Jr., John H. (1946). The Peat Deposits of Florida Their Occurrence, Development and Uses, Geological Bulletin No. 30. Florida Geological Survey.
- Rustan, Agne (February 1, 1998). Rock Blasting Terms and Symbols: A Dictionary of Symbols and Terms in Rock Blasting and Related Areas like Drilling, Mining and Rock Mechanics. Taylor & Francis. p. 83. ISBN 978-1-4665-7178-5.
Bulson, P.S. (July 24, 1997). Explosive Loading of Engineering Structures. CRC Press. p. 3. ISBN 978-1-135-82980-3.
- "BERKEFELD & AQUANTIS Water Treatment - Veolia Water Technologies". technomaps.veoliawatertechnologies.com.
- Amos Ives Root; Ernest Rob Root (March 1, 2005). The ABC And Xyz of Bee Culture. Kessinger Publishing. p. 387. ISBN 978-1-4179-2427-1.
- Fields, Paul; Allen, Sylvia; Korunic, Zlatko; McLaughlin, Alan; Stathers, Tanya (July 2002). "Standardized testing for diatomaceous earth" (PDF). Proceedings of the Eighth International Working Conference of Stored-Product Protection. York, U.K.: Entomological Society of Manitoba.
- Lartigue, E. del C.; Rossanigo, C. E. (2004). "Insecticide and anthelmintic assessment of diatomaceous earth in cattle". Veterinaria Argentina. 21 (209): 660–674.
- Fernandez, M. I.; Woodward, B. W.; Stromberg, B. E. (1998). "Effect of diatomaceous earth as an anthelmintic treatment on internal parasites and feedlot performance of beef steers". Animal Science. 66 (3): 635–641. doi:10.1017/S1357729800009206.
- Faulde, M. K.; Tisch, M.; Scharninghausen, J. J. (August 2006). "Efficacy of modified diatomaceous earth on different cockroach species (Orthoptera, Blattellidae) and silverfish (Thysanura, Lepismatidae)". Journal of Pest Science. 79 (3): 155–161. doi:10.1007/s10340-006-0127-8.
- "Diatomaceous Earth: Protect Food Storage". diatomaceousearth.com. Retrieved March 8, 2020.
- Capinera, John L. (2008). "Diatomaceous earth". In Capinera, John L. (ed.). Encyclopedia of Entomology (Second ed.). Springer. p. 1216. ISBN 978-1-4020-6242-1.
- "Pesticide Labeling Questions & Answers - Advertising Claims". EPA. Archived from the original on May 30, 2013. Retrieved July 7, 2013.
- Flynn, Thomas M. "Cryogenic Equipment and Cryogenic Systems Analysis." Cryogenic Engineering. Boca Raton etc.: CRC, 2005. Print.
- Nishimura, Shigeo (2001). Handbook of Heterogeneous Catalytic Hydrogenation for Organic Synthesis (1st ed.). New York: Wiley-Interscience. pp. 2–5. ISBN 9780471396987.
- "Prevention and Management of Insects and Mites in Farm-Stored Grain". Province of Manitoba. Archived from the original on October 18, 2013. Retrieved July 7, 2013.
- "21 CFR 573.340 - Diatomaceous earth" (PDF). Code of Federal Regulations (annual edition)—Title 21 - Food and Drugs—Part 573 - Food additives permitted in feed and drinking water of animals—Section 573.340 - Diatomaceous earth. Food and Drug Administration/U.S. Government Publishing Office. April 1, 2001. Retrieved February 9, 2016.
- "Diatomaceous Earth (DE)".
- Ferraz, E.; Coroado, J.; Silva, J.; Gomes, C.; Rocha, F. (2011). "Manufacture of ceramic bricks using recycled brewing spent kieselguhr". Materials and Manufacturing Processes. 26 (10): 1319–1329. doi:10.1080/10426914.2011.551908.
- Reka, Arianit A.; Pavlovski, Blagoj; Makreski, Petre (October 2017). "New optimized method for low-temperature hydrothermal production of porous ceramics using diatomaceous earth". Ceramics International. 43 (15): 12572–12578.
- Bidle, Kay D.; Azam, Farooq (February 1999). "Accelerated dissolution of diatom silica by marine bacterial assemblages". Nature. 397 (6719): 508–512. Bibcode:1999Natur.397..508B. doi:10.1038/17351.
- Zakharova, Yulia R.; Galachyants, Yuri P.; Kurilkina, Maria I.; Likhoshvay, Alexander V.; Petrova, Darya P.; Shishlyannikov, Sergey M.; Ravin, Nikolai V.; Mardanov, Andrey V.; Beletsky, Alexey V.; Likhoshway, Yelena V.; Mormile, Melanie R. (April 1, 2013). "The Structure of Microbial Community and Degradation of Diatoms in the Deep Near-Bottom Layer of Lake Baikal". PLOS ONE. 8 (4): e59977. Bibcode:2013PLoSO...859977Z. doi:10.1371/journal.pone.0059977. PMC 3613400. PMID 23560063.
- Washington, R.; Todd, M. C.; Lizcano, G.; Tegen, I.; Flamant, C.; et al. (2006). "Links between topography, wind, deflation, lakes and dust: The case of the Bodélé Depression, Chad" (PDF). Geophysical Research Letters. 33 (9): L09401. Bibcode:2006GeoRL..33.9401W. doi:10.1029/2006GL025827. ISSN 0094-8276.
- "NIOSH 1988 OSHA PEL Project Documentation: List by Chemical Name: SILICA, AMORPHO". CDC. September 19, 2018.
- "Diatomaceous Earth: Its Use and Precautions" (PDF). Archived from the original (PDF) on July 17, 2013. Retrieved November 9, 2013.
- "Occupational Health Guideline for Amorphous Silica" (PDF). CDC. September 1978. Archived (PDF) from the original on March 12, 2020. Retrieved March 24, 2020.
- "Wayback Machine" (PDF). July 10, 2003. Archived from the original (PDF) on July 10, 2003.
- "NIOSH Pocket Guide to Chemical Hazards - Silica, amorphous". CDC. Retrieved November 21, 2015.
- Hughes, Janet M.; Weill, Hans; Checkoway, Harvey; Jones, Robert N.; Henry, Melanie M.; Heyer, Nicholas J.; Seixas, Noah S.; Demers, Paul A. (1998). "Radiographic Evidence of Silicosis Risk in the Diatomaceous Earth Industry". American Journal of Respiratory and Critical Care Medicine. 158 (3): 807–814. doi:10.1164/ajrccm.158.3.9709103. ISSN 1073-449X. PMID 9731009.