Short Mayo Composite
The Short Mayo Composite was a piggy-back long-range seaplane/flying boat combination produced by Short Brothers to provide a reliable long-range air transport service to North America and, potentially, to other distant places in the British Empire and the Commonwealth.
|Image from a contemporary newspaper article, depicting Mercury atop Maia|
|Role||Transport seaplane carried to flight altitude by Short S.21 Maia|
|National origin||United Kingdom|
Robert H. Mayo
|First flight||5 September 1937|
|Introduction||14 July 1938|
|Primary users||Imperial Airways|
|Role||Flying-boat, launch aircraft for S.20 Mercury|
|National origin||United Kingdom|
Robert H. Mayo
|First flight||27 July 1937|
|Introduction||14 July 1938|
|Status||destroyed by enemy bombing 11 May 1941|
|Primary user||Imperial Airways|
Short Brothers had built the Empire flying boats which were capable of operating long range routes across the British Empire but could only attempt the trans-Atlantic route by replacing passenger and mail-carrying space with extra fuel.
It was known that aircraft could maintain flight with a greater payload than that possible during take off. Major Robert H. Mayo, the Technical General Manager at Imperial Airways, proposed mounting a small, long-range seaplane on top of a larger carrier aircraft, using the combined power of both to bring the smaller aircraft to operational height, at which time the two aircraft would separate, the carrier aircraft returning to base while the other flew on to its destination. The British Air Ministry issued Specification "13/33" to cover this project.
The Short-Mayo composite project, co-designed by Mayo and Shorts chief designer Arthur Gouge, comprised the Short S.21 Maia, [note 1] (G-ADHK) which was a variant of the Short "C-Class" Empire flying-boat fitted with a trestle or pylon on the top of the fuselage to support the Short S.20 Mercury(G-ADHJ).
Although generally similar to the Empire boat, Maia differed considerably in detail: the hull sides were flared and had "tumblehome" rather than being vertical as on the Empire to increase the planing surface (necessary for the higher takeoff weights); larger control surfaces; an increase in total wing area from 1,500 sq ft (140 m2) to 1,750 sq ft (163 m2); the engines were mounted further from the wing root to clear Mercury's floats and the rear fuselage was swept up to raise the tailplane relative to the wing. Like the Empire boats, Maia could be equipped to carry 18 passengers. Maia first flew (without Mercury) on 27 July 1937, piloted by Shorts' Chief Test Pilot, John Lankester Parker.
The upper component, Mercury, was a twin-float, four-engine seaplane crewed by a single pilot and a navigator, who sat in tandem in an enclosed cockpit. It could carry 1,000 lb (456 kg) of mail and 1200 Imperial gallons of fuel. Flight controls, except for elevator and rudder trim tabs, were locked in neutral until separation. Mercury's first flight, also piloted by Parker, was on 5 September 1937.
The mechanism that held the two aircraft together allowed for a small degree of movement. Lights indicated when the upper component was in fore-aft balance so trim could be adjusted prior to release. The pilots could then release their respective locks. At this point the two aircraft remained held together by a third lock which released automatically at 3,000 lb. The design was such that at separation Maia would tend to drop while Mercury would climb.
The first successful in-flight separation was carried out from the Shorts works at Borstal, near Rochester, Medway, on 6 February 1938, Maia piloted by Parker and Mercury by Harold Piper. Following further successful tests, the first transatlantic flight was made on 21 July 1938 from Foynes, on the Shannon Estuary, west coast of Ireland, to Boucherville, near Montreal, Quebec, Canada, a flight of 2,930 miles (4,714.4 km). Maia, flown by Captain A.S. Wilcockson, took off from Southampton carrying Mercury piloted by Captain Don Bennett. As well as Mercury, the launch aircraft Maia was also carrying 10 passengers and luggage. Mercury separated from her carrier at 8 pm to continue what was to become the first commercial [note 2] non-stop East-to-West transatlantic flight by a heavier-than-air machine. This initial journey took 20 hrs 21 min at an average ground speed of 144 mph (232 km/h).
The Maia-Mercury composite continued in use with Imperial Airways, including Mercury flying to Alexandria, Egypt, in December 1938. After modifications to extend Mercury's range, it established a record flight for a seaplane of 6,045 miles (9,726.4 km) from Dundee in Scotland to Alexander Bay, in South Africa between 6 and 8 October 1938.
Only one example of the Short-Mayo composite was built, the S.21 Maia with the registration G-ADHK and the S.20 Mercury G-ADHJ. The development of a more powerful and longer-range Empire boat (the Short S.26), the increase in allowable all-up weights with the standard "C-Class", the further development of in-flight refuelling and the outbreak of the Second World War combined to render the approach obsolete. Maia was destroyed in Poole Harbour by German bombers on 11 May 1941. Mercury was flown to Felixstowe for use by 320 (Netherlands) Squadron RAF a unit of the Royal Air Force formed from the personnel of the Royal Netherlands Naval Air Service. This squadron was based at the time at RAF Pembroke Dock. When this squadron was re-equipped with Lockheed Hudsons, Mercury was returned to Shorts at Rochester on 9 August 1941 and broken up so that its aluminium could be recycled for use in the war effort.
On the Tay Embankment close to the RRS Discovery there is a bronze plaque attached to the sea-wall. This commemorates the world record long-distance seaplane flight, at a location where the estuary and hills behind the take-off waters are seen. The plaque shows in raised relief the two aircraft still joined but reaching the altitude at which they would have separated. The plaque also contains wording including: - ″Commemoration of the 1938 flight of Captain Bennett from the Tay Estuary to South West Africa... The world record long-distance flight by a seaplane was achieved by the aircraft “Mercury”, the upper component of the Short Mayo... The two experimental planes ...were built by Short Brothers for Imperial Airways and designed to carry mail long distances without refueling... This tribute to the epic flight by Captain D.C.T. Bennett and First Officer Ian Harvey was unveiled by Captain Bennett's wife Mrs Ly Bennett and Lord Provost Mervyn Rollo on 4 October 1997.″
The concept also had an unusual legacy, since in 1976 NASA needed to transport the Space Shuttle between the Kennedy Space Centre and Edwards Air Force Base between each mission, and to get the craft airborne for gliding tests. A NASA engineer remembered the Mayo Composite, and NASA modified a second-hand Boeing 747 as the carrier aircraft accordingly.
Specifications (S.20 Mercury)Edit
Data from 
- Crew: 2 (pilot and navigator/radio operator)
- Capacity: 1,000 lb (450 kg) of mail
- Length: 51 ft 0 in (15.54 m)
- Wingspan: 73 ft 0 in (22.25 m)
- Height: 20 ft 3 in (6.17 m) 
- Wing area: 611 sq ft (56.8 m2)
- Empty weight: 10,163 lb (4,610 kg)
- Gross weight: 15,500 lb (7,031 kg) (solo - i.e. non-composite take-off)
- Composite launch weight:
- 20,800 lb (9,430 kg) (Normal composite launch weight)
- 26,800 lb (12,160 kg) (Record composite launch weight - Cape flight)
- Powerplant: 4 × Napier Rapier VI 16-cylinder "H-block" piston engines, 365 hp (272 kW) each
- Maximum speed: 212 mph (341 km/h; 184 kn)
- Cruise speed: 195 mph (314 km/h; 169 kn)
- Range: 3,900 mi (3,389 nmi; 6,276 km)
- Extended range: 6,100 mi (5,300 nmi; 9,820 km) (Cape flight)
- Wing loading: 33.6 lb/sq ft (164 kg/m2) 
Specifications (S.21 Maia)Edit
Data from 
- Crew: 3
- Capacity: 18 passengers
- Length: 84 ft 11 in (25.88 m)
- Wingspan: 114 ft 0 in (34.75 m)
- Height: 32 ft 7 1⁄2 in (9.944 m) 
- Wing area: 1,750 sq ft (163 m2)
- Empty weight: 24,745 lb (11,224 kg)
- Gross weight: 27,700 lb (12,565 kg) (limit on weight of Maia for composite launching)
- Max takeoff weight: 38,000 lb (17,237 kg)
- Powerplant: 4 × Bristol Pegasus XC nine-cylinder radial engines, 919 hp (685 kW) each
- Maximum speed: 200 mph (322 km/h; 174 kn)
- Range: 850 mi (739 nmi; 1,368 km)
- Service ceiling: 20,000 ft (6,100 m)
In popular cultureEdit
Aircraft of comparable role, configuration and era
- Barnes C.H. & James D.N. Shorts Aircraft since 1900. London (1989): Putnam. p. 560. ISBN 0-85177-819-4.
- "World News: Sir Arthur Gouge". Flight International, 25 October 1962, page 660
- Flight 19 August 1937 p180
- J Lankester Parker OBE FRAeS Hon MSLAE started as a test pilot at Shorts in 1916, was Chief Test Pilot 1918 - 1945 and from 1943 a Director of Short Brothers and Harland, Belfast
- Jackson 1974, p. 302
- Flight 17 February 1938
- Also contains an eye-witness account of the first in-flight separation Archived 18 November 2008 at the Wayback Machine
- Captain Bennett was later the first commander of the RAF Pathfinder Force in WWII and became an Air Vice Marshal
- "Mercury makes good" p80
- "Mercury makes good" Flight 28 July 1938. pp79-80
- Cassidy, Brian (2004). Flying Empires - Short ‘C’ class Empire flying boats. Queens Parade Press. p. 58. ISBN 0-9529298-2-1.
- Barnes and James, p.311
- "Mercury Seaplane's long-distance flight record; Scottish Visitor""Scottish Visitor - Mercury Seaplane". Retrieved 18 November 2017.[permanent dead link]
- White, Rowland (2018). Into the Black. London: Bantam Press. p. 129. ISBN 978-0-593-06436-8.
- Barnes & James 1989, p. 312.
- Barnes 1967, p. 305.
- Angelucci 1984, p.226.
- Jackson, A.J. (1974). British Civil Aircraft since 1919 Volume 3. London: Putnam. ISBN 0-370-10014-X.
- Angelucci, Enzo (1984). World Encyclopedia of Civil Aircraft. London: Willow Books. ISBN 0-00-218148-7.
- Composite Aircraft Flight 1935
- The Great Experiment Flight 1937
- "Short Mayo - The Composite Aircraft Described in Detail" (PDF). Flight. Reed Business Information Ltd. XXXIII (1521): (Supplement at p.159.). 17 February 1938. Retrieved 7 July 2011.
|Wikimedia Commons has media related to Short Mayo Composite.|
|British Movietone News film footage|
- 1935 article describing the proposed Short-Mayo Composite
- "Flying Boat Launches Sea Mail Plane in Air" Popular Mechanics, April 1935, article with drawing explaining concept of purposed Short Mayo Composition.
- Aero Stories
- Contemporary article in Time magazine, 14 February 1938
- Irish Inland Waterway News, Winter 2001
- Imperial Airways history
- Image of the Maia/Mercury at www.historyofaircargo.com
- Download link for "The Guild of Aircraft Pilots and Navigators of London 1929 - 2004"
- Winchester, Clarence, ed. (1938), "The Short-Mayo aircraft", Wonders of World Aviation, pp. 25–29
|Sequence of photos taken during first public separation (at Flight PDF Archive)|