Johnston Atoll Chemical Agent Disposal System (JACADS) was the U.S. Army's first chemical munitions disposal facility. It was located on Johnston Island, at Johnston Atoll and completed its mission and ceased operation in 2000.
|Sulfur mustard (HD)||578,339.6 pounds (262,330.4 kg)|
|Sarin (GB)||2,639,462.4 pounds (1,197,240.0 kg)|
|VX nerve agent||845,418.3 pounds (383,475.3 kg)|
Prior to the beginning of destruction operations at JACADS, the atoll held about 6.6% of the entire U.S. stockpile of chemical weapons. Chemical weapons were stockpiled on Johnston Atoll beginning in 1971, including weapons transferred from Okinawa during the 1971 Operation Red Hat. Some of the other weapons stored at the site, including Sarin (GB) and VX Nerve Agent, were shipped from U.S. stockpiles in Germany in 1990. The shipments followed a 1986 agreement between the U.S. and Germany to move the munitions. The remainder of the chemical weapons were a small number of World War II era weapons shipped from the Solomon Islands. In 1985, the U.S. Congress mandated that all chemical weapons stockpiles at Johnston Atoll, mostly mustard and nerve agents, be destroyed.
Planning for JACADS began in 1981 and initial construction started in 1985–1986. In August 1985, the U.S. Environmental Protection Agency (EPA) issued a 10-year permit to the Army allowing it to construct and operate JACADS. As JACADS was preparing to begin operations, the U.S. Congress passed Public Law 100-456, which required JACADS to complete operational verification testing (OVT) to ensure each type of munition could be disposed of safely. Operations began at JACADS in June 1990, commencing with operational verification testing.
The first weapon disposal took place on June 30, 1990. That day, JACADS became the first U.S. chemical weapons disposal facility. The OVT phase of operations lasted until March 1993. Transition from the testing phase to full-scale operations began in May 1993 and, in August, full-scale operations began. Twice, in 1993 and 1994, the facility had to be evacuated because of hurricanes; operations were delayed for as long as 70 days during these periods.
On November 29, 2000, the last of the chemical weapons at JACADS were disposed of. The last disposal operation destroyed more than 13,000 VX filled land mines. Two years after the last chemical weapons at JACADS were destroyed, the Army submitted the plan to dismantle the facility to the EPA; it was approved in September 2002. Demolition on the 80,000-square-foot (7,400 m2) facility, home to the incinerators, laboratories and control rooms, took place from August–October 2003. In November 2003 a plaque was dedicated to JACADS personnel.
JACADS workers utilized incineration to destroy the chemical agents at Johnston Atoll. After workers loaded the weapons onto a conveyor, automated equipment would take over the process. The equipment removed the explosive component of the weapon and drained the chemical agent. The explosive and chemical agent were then incinerated at high temperature. The metal weapons casings were then thermally decontaminated and scrapped.
By early 1996, the facility at Johnston Atoll had destroyed about 3.5% of the overall U.S. chemical weapons stockpile. Included in that amount, out of total stockpile of 31,000 tons, was two million pounds of mustard and nerve agents destroyed by JACADS. The disposal program was overseen by Project Manager Gary McCloskey, and during the ten years from 1990–2000 was responsible for the destruction of over 400,000 chemical rockets, projectiles, bombs, mortars, ton containers, and mines. Also destroyed at JACADS were over 2,000 tons of the nerve agents sarin and VX, as well as the blister agent HD. In total, the program at Johnston Atoll destroyed 412,000 individual chemical munitions.
Accidents and incidentsEdit
There were a few chemical weapons related accidents during the period JACADS was in operation. In January 1993, the burster charge on a 105 mm artillery shell ignited. The shell contained World War II-era mustard gas, though none was released and the incident resulted in no injuries. A later incident on March 23, 1994 resulted in the accidental release of sarin gas after a chemical agent line was opened for maintenance without properly purging the line with fuel oil. The incident led to a $122,000 fine against the Army from the EPA. Another incident in November 1994 led to the explosion of a drained chemical rocket during mechanical removal of the fuse, but no leaks were reported.
On December 9, 1993, a spill of about 500 pounds (226 kg) of Sarin (Agent GB) occurred inside the Munitions Demilitarization Building (MDB). There was no agent migration outside the building and the contingency plan was not activated. The facility suspended processing of munitions until investigation of the incident was satisfactorily completed.
The U.S. National Research Council's Committee on Evaluation of Chemical Events at Army Chemical Agent Disposal Facilities was provided, by the Army, with a list of 39 incidents that occurred at JACADS from its opening until its closure. Of those 39 events, 24 were classified as chemical in nature. For example, five days after the last chemical weapons were destroyed at JACADS, VX was detected in ash from the incinerator. The committee's evaluation of JACADS incidents was published in 2002.
Response and reactionEdit
The 1990 shipments of nerve agents from West Germany to JACADS caused several South Pacific nations to express unease. At the 1990 South Pacific Forum in Vanuatu, the island nations of the South Pacific indicated that their concern was that the South Pacific would become a toxic waste dumping ground. Other concerns raised included the security of the shipments, which were refueled at sea and escorted by U.S. guided missile destroyers, while they were en route to Johnston Atoll. In Australia, Prime Minister Bob Hawke drew criticism from some of these island nations for his support of the chemical weapons destruction at Johnston Atoll.
- Pike, John. "Johnston Atoll", Globalsecurity.org, accessed October 25, 2008.
- "Chemical Weapons Destruction Complete on Johnston Atoll", (Press release), U.S. Department of Defense, November 30, 2000, accessed October 25, 2008.
- Broadus, James M., et al. The Oceans and Environmental Security: Shared U.S. and Russian Perspectives, (Google Books), p. 103, Island Press, 1994, (ISBN 1559632356), accessed October 25, 2008.
- "A Success Story: Johnston Atoll Chemical Agent Disposal System Archived 2012-09-15 at the Wayback Machine", U.S. Army Chemical Materials Agency, accessed October 25, 2008.
- Kakesako, Gregg K. "Johnston Atoll: The end of an era", Honolulu Star-Bulletin, November 6, 2003, accessed October 25, 2008.
- "Johnston Atoll Chemical Agent Disposal System (JACADS)", U.S. Environmental Protection Agency, updated July 27, 2007, accessed October 25, 2008.
- Mauroni, Albert J. America's Struggle with Chemical-Biological Warfare, (Google Books), Greenwood Publishing Group, 2000, p. 245, (ISBN 0275967565).
- Mauroni, Albert J. Chemical Demilitarization: Public Policy Aspects, (Google Books), Greenwood Publishing Group, 2003, p. 116, (ISBN 027597796X).
- JACADS: Defining a Moment in Chemical Weapons History Archived 2011-05-16 at the Wayback Machine", U.S. Army Program Manager for Chemical Demilitarization, accessed October 25, 2008.
- Koplow, David A. By Fire and Ice: Dismantling Chemical Weapons While Preserving the Environment (Google Books), Routledge, 1997, p. 85, (ISBN 905699560X), accessed October 25, 2008.
- "Mission accomplished: JACADS safely destroys over 400,000 chemical weapons on Johnston Island", (Press release), U.S. Environmental Protection Agency, updated July 27, 2007, accessed October 25, 2008.
- "Report on Emergency Incidents at Hazardous Waste Combustion Facilities and Other Treatment, Storage, and Disposal Facilities, (TSDFs), April 19, 1999" (PDF). US Environmental Protection Agency. Retrieved July 26, 2012.
- Committee on Evaluation of Chemical Events at Army Chemical Agent Disposal Facilities. Evaluation of Chemical Events at Army Chemical Agent Disposal Facilities, (Google Books), p. 19, U.S. National Research Council, National Academies Press, 2002, (ISBN 0309086299).
- Anderson, Ian. "Protests grow over nerve gas disposal", New Scientist, August 11, 1990, accessed October 26, 2008.
- Cooper, Andrew Fenton, et al. Relocating Middle Powers: Australia and Canada in a Changing World Order, (Google Books), UBC Press, 1993, p. 148, (ISBN 0774804505), accessed October 25, 2008.
- McCloskey, Gary. "Johnston Atoll Chemical Agent Disposal System Mines Its Business[permanent dead link]", Army Chemical Review, August 2001, via FindArticles.com, accessed October 25, 2008.
- Schreiber, E. A., Doherty, Jr., Paul F. and Schenk, Gary A. "Effects of a Chemical Weapons Incineration Plant on Red-Tailed Tropicbirds", (JSTOR), The Journal of Wildlife Management, Vol. 65, No. 4 October 2001, pp. 685–695
- U.S. National Research Council: Committee on Review and Evaluation of the Army Chemical Stockpile Disposal Program, Closure and Johnston Atoll Chemical Agent Disposal System, (Google Books), National Academies Press, 2002, (ISBN 0309084059).
- Chemical Weapons Disposal Dispute", T.E.D. Case Study, "The Mandala Project", American University, May 1997, accessed October 25, 2008.
- "Johnston Island", U.S. Army Chemical Materials Agency, official site, accessed October 25, 2008.
- Cleanup of Johnston Atoll Missile Launch Facility, DOD FOIA declassified document. 24Mb.