Cecil Kelley criticality accident
Coordinates: A criticality accident occurred on December 30, 1958, at the Los Alamos National Laboratory in Los Alamos, New Mexico, in the United States. It is one of only ten such events to occur outside of a nuclear reactor, though it was the third such event to take place in 1958 after events on 16 June  at the Y-12 Plant in Oak Ridge, Tennessee, and on 15 October at the Vinča Nuclear Institute in Vinča, Yugoslavia. The accident involved plutonium compounds dissolved in liquid chemical reagents, and it killed one man, Cecil Kelley, a chemical operator, by severe radiation poisoning, within 35 hours.
Context of the accidentEdit
Cecil Kelley was a 38-year-old chemical operator with 11 years of experience, with more than half of those hours at the Los Alamos lab, where one of his duties was to operate a large (1000-liter capacity) stainless-steel mixing tank. The tank contained residual plutonium-239 remaining from other experiments and applications, along with various organic solvents and acids in an aqueous solution for the purpose of recovering it for reuse. In pure form and under normal temperature and pressure conditions, plutonium – a mostly man-made element existing in trace amounts in nature – is a solid silvery metal. It tarnishes quickly when exposed to air and readily dissolves in concentrated hydrochloric, hydroiodic, and perchloric acids, as well as others. On the day of the accident the mixing tank was supposed to contain what nuclear chemists call a "lean" concentration of dissolved plutonium (≤0.1 g of plutonium per liter of solution) in a bath of highly corrosive nitric acid and a caustic stabilized aqueous organic emulsion. However, as a result of what were later determined to be at least two "improper transfers" of plutonium waste to the tank (the sources of which were never determined, or at least never publicly disclosed, and about which Kelley had neither reason to suspect nor ability to observe), the concentration of plutonium in the mixing tank on this particular occasion was nearly 200 times higher. Worse, it was also distributed unevenly: the upper layer of solution had especially high concentrations and contained a total of over 3 kg of plutonium, which was already close to criticality before Kelley acted. When Kelley switched on the mixer, a vortex began to form. The denser aqueous layer within the tank immediately pushed outward and upward forming a "bowl", and the less dense plutonium-rich layer swirled toward the vessel's center.
Among other ideal characteristics, the ideal shape for any fissile substance to become supercritical is the shape of least surface area, a sphere. Although the plutonium-rich solution was not spherical, the vortex made it thicker in the center, and this, along with the corresponding increase in density and the neutron reflectivity of the aqueous layer surrounding it, caused the dissolved plutonium to reach and cross the criticality threshold in approximately one second: neutrons within the mixture began to bombard the nuclei of the solution's plutonium atoms with sufficient frequency to cause these atoms to break apart and release other neutrons in a sustained nuclear chain reaction lasting only 200 microseconds but releasing a huge burst of neutrons and gamma radiation. Such an uncontrolled release of nuclear energy is often referred to as an excursion. Within 3 seconds, the layers in the mixture had become dispersed, and no further excursions were possible.
Events of the excursionEdit
Kelley had been standing on a foot ladder looking at the contents of the mixing tank through a viewing window when the excursion event occurred. Two other technicians working within the laboratory witnessed a bright flash of blue light followed by the sound of a thud. The power burst either caused Kelley to collapse or knocked him off the ladder, and he had fallen to the ground. He arose disoriented, and apparently switched the mixer off and then back on again before running outside of the building. The other technicians found him there in the snow in a state of ataxia (uncoordinated muscle movement) and only able to say to them, "I'm burning up! I'm burning up!"
Because the possibility of an excursion taking place in a mixing tank had been considered to be virtually non-existent, the technicians decided that Kelley must have somehow been exposed to either alpha radiation, the acid bath, or both, and one of them took him to a chemical shower while the other switched off the mixer. Additional staff members arrived on the scene within minutes to find Kelley virtually unconscious. The bright pink color of his face indicated erythema (redness of the skin) brought on by cutaneous radiation syndrome.
Any accident at Los Alamos involving a radioactive substance requires an immediate investigation by a team of radiation monitoring staff. Even before Kelley was taken to an emergency room, these staff members began an examination of the mixing room with radiation detectors capable of assessing the alpha radiation emitted by escaped plutonium. Alpha activity would have been widespread if any of the plutonium mixture had escaped the tank, but none was found. Eighteen minutes later, the team began searching for gamma radiation, and were surprised to find intense gamma radiation near the mixing tank, on the order of tens of rads per hour. Such intense gamma radiation could only be produced by significant amounts of fission product; this, combined with the otherwise inexplicable flash of light reported by the other two technicians, was sufficient to confirm that a criticality accident had occurred.
Kelley's clinical courseEdit
For the first hour and forty minutes following the accident, Kelley had been incoherent, and had gone through waves of intense vomiting and retching. He then stabilized, was able to once again converse normally, and was able to have his pulse taken and his blood drawn. The blood draw indicated that Kelley had been exposed to approximately 9 Gy from fast neutrons and 27 Gy from gamma rays, for a total of 36 Gy. For an adult human, exposure to 2 Gy from an unfocused radiation source such as an excursion will cause radiation sickness but is not considered definitely lethal; 2.4–3.4 Gy is the median lethal dose; a dose of 5 Gy almost always kills. Kelley had received more than seven times the adult human lethal dose. Although the medical staff in the emergency room took steps to ease his pain with Demerol and morphine, previous research on radiation exposure in animals indicated Kelley's death was inevitable. Within six hours his lymphocytes were all but gone. A bone biopsy performed 24 hours after the incident produced bone marrow that was watery and contained no red blood cells. Numerous blood transfusions had no lasting helpful effect: 35 hours after his initial exposure and after a final bout of intense restlessness, agitation, sweating, becoming ashen-skinned, and having an irregular pulse, Cecil Kelley died of heart failure.
This section may lend undue weight to certain ideas, incidents, or controversies. (May 2012) (Learn how and when to remove this template message)
An investigation into the circumstances of the accident never resulted in a public explanation of how the mixing tank became filled with such a high concentration of plutonium—initially the blame was placed on Kelley himself.
Although Kelley had neither ingested nor inhaled any plutonium during the accident, he, like many laboratory technicians at Los Alamos, had been exposed to minute particles of airborne plutonium over the course of several years. An event such as this was therefore considered an "experiment of opportunity." Careful records were kept of every moment of Kelley's life from accident through death and onto the autopsy table. His organs were kept for pathological examination and their plutonium levels analyzed. The results of these tissue analyses were considered fundamental to understanding what would happen to a population during a nuclear attack and impossible to obtain any other way. Although the bone marrow biopsy of Kelley's sternum was performed under the premise that the physicians wished to determine if he were a candidate for a bone marrow transplant, Kelley's death was inevitable, and an actual transplant was not seriously considered.
Kelley's death left a widow, Doris Kelley, and two children, then aged eight years and 18 months. Doris Kelley did not receive notification while he was still alive that her husband had been irradiated, and only learned of his death from the laboratory authority when representatives visited her at her home shortly afterward. Assuring her verbally that they would provide her with financial compensation for her husband's death, they convinced her not to file any lawsuits against the laboratory. Despite such assurances, the only compensation Doris Kelley received was a lifetime-level position working for the lab itself at near-poverty levels, until health reasons caused her to retire.
In 1996, Doris Kelley and her daughter, Katie Kelley-Mareau, filed a lawsuit against Dr. Clarence Lushbaugh, the pathologist who performed the autopsy on Cecil Kelley. The case alleged the misconduct of doctors, the hospital, and the administration of Los Alamos in removing organs from the deceased without consent from next-of-kin over a span of many years (1958–1980). Kelley's autopsy was the first instance of this type of post-mortem analysis, but there were many more performed by Lushbaugh and others in later years at Los Alamos. During a deposition for the case, Lushbaugh, when asked who gave him the authority to take eight pounds of organs and tissue from Kelley's body, said, "God gave me permission." The class action suit was settled by the defendants for about $9.5 million in 2002 and an additional $800,000 in 2007. None of the defendants admitted any wrongdoing.
- ACCIDENTAL RADIATION EXCURSION AT THE Y-12 PLANT (PDF) (Report). 1958. Y-1234.
- Miner, William N.; Schonfeld, Fred W. (1968). "Plutonium". In Clifford A. Hampel (editor). The Encyclopedia of the Chemical Elements. New York (NY): Reinhold Book Corporation. pp. 540–546. LCCN 68-29938.CS1 maint: Extra text: editors list (link)
- McLaughlin, Thomas P.; Monahan, Sean P.; Pruvost, Normal L. (May 2000). A review of criticality accidents: 2000 revision (PDF). Los Alamos, New Mexico: Los Alamos National Laboratory. p. 16.
- Welsome, Eileen (1999). The plutonium files: America's secret medical experiments in the Cold War. New York: Dell Publishing. ISBN 978-0-307-76733-2.
- McInroy, James F. (1995). "A true measure of plutonium exposure: the human tissue analysis program at Los Alamos" (PDF). Los Alamos Science. 23: 235–255.
- Harold, Catherine (ed.). Professional guide to diseases (9th ed.). Philadelphia, PA: Lippincott Williams & Wilkins. ISBN 978-0-7817-7899-2. OCLC 475981026.
- Shipman, T.L. (1961). Diagnosis and treatment of acute radiation injury. New York: International Documents Service. pp. 113–133. OCLC 2717622.
- "The Cecil Kelley Criticality Accident: The Origin of the Los Alamos Human Tissue Analysis Program" (PDF). Los Alamos Science. 23: 250–251. 1995.
- Doris E. Kelley, et al. v Regents of the University of California, et al, settled (Santa Fe County District Court, New Mexico 1996). SF-96-2430. This case was settled by all defendants.
- Tucker, Todd (2009). Atomic America: How a Deadly Explosion and a Feared Admiral Changed the Course of Nuclear History. New York: Free Press. ISBN 978-1-4165-4433-3. See summary: 
- Andrews, L; Nelkin, D (1998). "Whose body is it anyway? Disputes over body tissue in a biotechnology age" (PDF). Lancet. 351 (9095): 53–7. doi:10.1016/S0140-6736(05)78066-1. PMID 9433437.
- See Stewart Settlement, the second of 2 settlements in this case.